Toronto Commercial HVAC repairs walk-in coolers for restaurants, grocery stores, convenience stores, catering kitchens, breweries and food distributors across Toronto and the GTA. Our 313A licensed mechanics carry Heatcraft, Russell, Bohn and Copeland parts and answer walk-in failures on a 24-hour priority line.
Walk-in coolers usually fail for four reasons. Refrigerant leaks at flare fittings, valves and coil joints slowly drain capacity. Condenser coils load with grease, lint and dust until head pressure climbs and the compressor overheats. Defrost or airflow problems ice up the evaporator. Torn door gaskets and worn closers let warm, humid air in all day, so the system never catches up.
Repairs typically cost $450 to $3,200, plus a $225 refrigeration diagnostic. Every repair ends with a temperature log back to setpoint.
What Does Walk-In Cooler Repair Cover?
Condensing unit
Compressors, condenser fan motors, coils, contactors, pressure controls and refrigerant circuits, whether the unit sits on the roof, in a rear lane or on top of the box.
Evaporator
Evaporator coils, fan motors, expansion valves, drain pans and drain line heaters.
Controls
Electronic controllers, thermostats, temperature probes and alarms.
Box and doors
Door gaskets, closers, hinges, door heaters, strip curtains and panel damage.
Walk-In Cooler Troubleshooting Guide
| Symptom | Likely cause | Typical repair |
|---|---|---|
| Box warm, unit running | Dirty condenser or low charge | Coil cleaning, leak repair |
| Box warm, fans off | Fan motor or controller | Fan motor, controller |
| Ice on evaporator | Low airflow, low charge, door open | Fan, leak repair, door fix |
| Water on floor | Plugged drain or failed heater | Drain clearing, heater |
| Door will not seal | Torn gasket, worn closer | Gasket and closer |
| Compressor clicking off | Overheating or electrical | Coil cleaning, relay, compressor |
When to Call for Walk-In Cooler Repair
- Box temperature above 4C.
- Condensing unit running constantly.
- Ice building on the evaporator.
- Water pooling on the floor.
- Door not closing or sealing.
- Unusual noises from the condensing unit.
Repair or Replace the Condensing Unit?
Most walk-in repairs are well worth doing. If a condensing unit past 12-15 years loses its compressor, or the system uses a phased-out refrigerant and has a major leak, a new condensing unit is often the better buy. We quote both in writing. Freezer-specific problems are covered on walk-in freezer repair.
Walk-In Cooler Repair Across Toronto and the GTA
We repair walk-ins in Chinatown and Spadina restaurants, Entertainment District bars and kitchens, Woodbridge delis, Agincourt and Markham-Lawrence grocers and convenience stores across the GTA. To stop repeat calls, add commercial refrigeration maintenance, and for other refrigerated equipment see commercial refrigeration repair.
